Sand Replacement By Marble Powder
Home > Products > Sand Replacement By Marble Powder

Sand Replacement By Marble Powder

sand replacement by marble powder - pod

replacement of sand by marble powder in ncrete. Partial Replacement of Cement With Marble Powder in Concrete. Partial replacement of marble powder in cement accordingly in the range of 20 30 40 by weight for M20 grade of concrete. With this experimental research work the problem of waste production management of this agro waste are will be solved.

Read More

Marble Powder As A Partial Replacement Of Sand -

Marble Powder As A Partial Replacement Of Sand 1454 Words 6 Pages V. CONCLUSION From the test results it is clearly evident that granite powder as a partial replacement of sand proves to be beneficial when Durability properties of Concrete is considered.

Read More

Use of Waste Marble Powder as Partial Replacement

It can be observed that the flexure strength for the concrete mix containing 10% of marble powder dust in cement got increased by the value of 9.2% and for 10% replacement with sand the flexure strength also got increased about 9.3% but it decreased when the mix contains 20% marble powder dust against cement (10%) and sand(10%) about 10%.

Read More

Partial replacement of sand with marble waste and

2020-11-2 · At 100% combined replacement rate of sand with marble waste and scoria there is a significant reduction of a slump by 60% (30 mm) due to the significant increment of water demand at the full replacement of sand with marble waste and scoria This argument also revealed by Moreover, to easily understand the difference, the result is shown ...

Read More

A study of the chemical effect of marble and granite ...

2020-2-4 · For sand replacement, and by replacing 10% of sand with marble powder in (NF10), the compressive strength value rises up to 5% above the control CM. Replacing 5% of cement and 10% of sand with marble waste powder in NC5 + NF10 mix gives almost the same compressive strength value obtained from CM.

Read More

Influence of limestone waste as partial replacement ...

2020-4-10 · Influence of limestone waste as partial replacement material for sand and marble powder in concrete properties Omar M. Omar a, Ghada D. Abd Elhameed b,*, Mohamed A. Sherif a, Hassan A. Mohamadien c a Department of Civil Construction and Architecture, Faculty of Industrial Education, Suez, Egypt b Building Materials Research and Quality Control Institute, Housing and Building National

Read More

Experimental study on partial replacement of cement by ...

2017-7-5 · Abstract-The present study is aimed at utilizing Waste marble powder and quarry sand as partial replacement of cement and fine aggregate in concrete and comparing it with conventional concrete. This experimental investigation is carried out in three phases in 1st phase M20 grade of concrete is produced

Read More

INFLUENCE OF SILICA FUME, MARBLE POWDER, GRANITE

2018-11-30 · based upon cement or sand replacement by the marble powder. Results obtained that 10% substitution of sand by the marble powder provided maximum compressive strength at about the same workability. Moreover, an even more positive effect of marble powder is

Read More

Properties of concrete incorporating sand and cement

2016-12-9 · 10% marble powder as partial replacement of cement and MX3 with 15% marble powder as partial replacement of sand, MX4 with 15% marble powder as partial replacement of cement and also MX5 with 20% marble powder as partial replacement of cement and sand together and MX6 with 30% marble powder dust as partial replacement of cement and sand ...

Read More

PARTIAL REPLACEMENT OF CEMENT AND FINE

3. Use of marble waste powder shows a great performance due to the efficient micro filling ability 4. it, marble powder when replacing with sand up to certain percentage shows almost same strength. 5.

Read More

Marble Powder As A Partial Replacement Of Sand -

Marble Powder As A Partial Replacement Of Sand 1454 Words 6 Pages V. CONCLUSION From the test results it is clearly evident that granite powder as a partial replacement of sand proves to be beneficial when Durability properties of Concrete is considered.

Read More

sand replacement by marble powder - pod

replacement of sand by marble powder in ncrete. Partial Replacement of Cement With Marble Powder in Concrete. Partial replacement of marble powder in cement accordingly in the range of 20 30 40 by weight for M20 grade of concrete. With this experimental research work the problem of waste production management of this agro waste are will be solved.

Read More

Use of Waste Marble Powder as Partial Replacement in ...

2019-7-1 · the partial replacement with sand having 10% marble dust powder. But the split tensile strength decreased for the mix which contains 20 % marble powder dust against cement (10%) and sand (10%) by 11%. Hence result shows that marble powder when mixed with sand and cement together

Read More

Influence of limestone waste as partial replacement ...

2020-4-10 · Influence of limestone waste as partial replacement material for sand and marble powder in concrete properties Omar M. Omar a, Ghada D. Abd Elhameed b,*, Mohamed A. Sherif a, Hassan A. Mohamadien c a Department of Civil Construction and Architecture, Faculty of Industrial Education, Suez, Egypt b Building Materials Research and Quality Control Institute, Housing and Building National

Read More

Experimental Utilization of Marble Dust Powder as Partial ...

2018-3-13 · 20% marble powder dust as partial replacement of cement and sand together and also MX3 with 15% marble powder as partial replacement of sand, MX4 with 15% marble powder dust as partial replacement of cement and MX6 with 30% marble powder dust as partial replacement of cement and sand together. S.No. Characterist ics Specified value as per IS ...

Read More

Valorization of marble’s waste as a substitute in sand ...

increased of 7% when using 50% of limestone replacement with marble. Tensile and flexural strength increased too, especially with 15% of admixture of marble powder. However, strengths became lower when replacement ratio was more than 50%. Aliabdo et al. (2014) studied the effect of cement replacement and sand replacement in concrete by

Read More

Partial Replacement of Cement With Marble Powder

Marble powder: The marble dust is obtained from RAK ceramics. The specific gravity of tile dust is found to be 2.62 and the fineness is found to be 7.5%. 3.METHODOLOGY: The evaluation of tile powder which is used as a replacement of cement material begins with the concrete testing.

Read More

Properties of concrete incorporating sand and cement

2016-12-9 · 10% marble powder as partial replacement of cement and MX3 with 15% marble powder as partial replacement of sand, MX4 with 15% marble powder as partial replacement of cement and also MX5 with 20% marble powder as partial replacement of cement and sand together and MX6 with 30% marble powder dust as partial replacement of cement and sand ...

Read More

Abrar Awol.pdf - USING MARBLE WASTE POWDER IN

Replacement of sand by marble waste powder from 5-20% ranges, in concrete production, results in similar and mostly enhanced performance than the control concrete specimens; with similar compressive strength to the control specimens, with slump improvement and water permeability depth reduction than the control specimens in both C-25 and C-50 ...

Read More

Marble powder - SlideShare

2016-9-11 · Marble powder 1. BY P.ROHITH S.NIHARIKA A.RANJITH B.AKSHAY P.JEEVAN Partial Replacement of Cement with Marble Powder 2. Objective of the project Introduction Nominal Mx Design Test Results and Graphs Conclusion Contents 3. Composition of Marble powder 4.

Read More

Marble Powder As A Partial Replacement Of Sand -

Marble Powder As A Partial Replacement Of Sand 1454 Words 6 Pages V. CONCLUSION From the test results it is clearly evident that granite powder as a partial replacement of sand proves to be beneficial when Durability properties of Concrete is considered.

Read More

An Experimental investigation on utilizations of

2021-1-25 · The durability as well as workability has increased to large extent by use of marble dust as replacement of fine aggregate and coarse aggregate. The effect on properties of concrete were investigated and concluded that optimum percentage for replacement of sand with marble powder in concrete is almost 50% [1-9].

Read More

Experimental Utilization of Marble Dust Powder as Partial ...

2018-3-13 · 20% marble powder dust as partial replacement of cement and sand together and also MX3 with 15% marble powder as partial replacement of sand, MX4 with 15% marble powder dust as partial replacement of cement and MX6 with 30% marble powder dust as partial replacement of cement and sand together. S.No. Characterist ics Specified value as per IS ...

Read More

Valorization of marble’s waste as a substitute in sand ...

increased of 7% when using 50% of limestone replacement with marble. Tensile and flexural strength increased too, especially with 15% of admixture of marble powder. However, strengths became lower when replacement ratio was more than 50%. Aliabdo et al. (2014) studied the effect of cement replacement and sand replacement in concrete by

Read More

Abrar Awol.pdf - USING MARBLE WASTE POWDER IN

Replacement of sand by marble waste powder from 5-20% ranges, in concrete production, results in similar and mostly enhanced performance than the control concrete specimens; with similar compressive strength to the control specimens, with slump improvement and water permeability depth reduction than the control specimens in both C-25 and C-50 ...

Read More

Research Paper PARTIAL REPLACEMENT OF CEMENT

2012-5-16 · Particles of this sand have smooth texture and are blackish. Sieve analysis was done to find out fineness modulus which comes out to be 3.14% which is under limit as per IS 383-1970. The test conducted on Sand is shown in Table No. 3. Table 3: Sand Marble powder: Marble powder

Read More

Properties of concrete incorporating sand and cement

2016-12-9 · 10% marble powder as partial replacement of cement and MX3 with 15% marble powder as partial replacement of sand, MX4 with 15% marble powder as partial replacement of cement and also MX5 with 20% marble powder as partial replacement of cement and sand together and MX6 with 30% marble powder dust as partial replacement of cement and sand ...

Read More

Partial Replacement of Fine Aggregates with Quarry Dust ...

2018-6-15 · river sand. Quarry dust and Marble powder contains similar properties as that of river sand and hence accepted as a building material. The present paper focuses on investigating maximum percentage replacement of river sand by Quarry dust and Marble powder in varying equal percentages 0%, 10%, 20%, 30%, 40%, 50%, and 60% for M25 mix designations.

Read More

Marble powder - SlideShare

2016-9-11 · Marble powder 1. BY P.ROHITH S.NIHARIKA A.RANJITH B.AKSHAY P.JEEVAN Partial Replacement of Cement with Marble Powder 2. Objective of the project Introduction Nominal Mx Design Test Results and Graphs Conclusion Contents 3. Composition of Marble powder 4.

Read More